Sectional Point Repair in Westminster

One city, one building boom

Westminster was a farm town of bean fields and dairies until the mid-1950s, incorporated in 1957, and was essentially built out by 1970. Almost every house in the city, from the tracts along Westminster Boulevard and Bolsa Avenue to the neighborhoods around Little Saigon and the streets east of Beach Boulevard, was plumbed in that window with vitrified clay laterals in short jointed lengths. The earliest tracts are raised-floor houses with cast iron under the floor; by the early 1960s most were slab-on-grade with cast iron beneath the slab and clay from the foundation out to the street. The small unincorporated pocket of Midway City in the middle of town is older, with some 1920s to 1940s houses on the oldest clay in the area, and a few streets that stayed on septic longer than the rest.

Because the housing stock is so uniform, the failures are too. Clay joints open and admit roots. Cast iron under the slab channels out along the bottom over sixty years, so a camera sees a clean crown above a pipe that is nearly gone underneath. Almost no house in Westminster has ABS or PVC in the original lateral, which is unusual for Orange County and worth knowing when a contractor quotes.

Shallow groundwater and heavy clay

Westminster sits on the flat coastal plain a few miles from the Bolsa Chica wetlands, and the water table under much of the city is shallow, especially on the west side toward Huntington Beach and Seal Beach. In a wet winter it rises to the level of the laterals. Groundwater enters at every open clay joint, carries fine soil with it, and leaves voids around the pipe that let it settle and belly. Roots from the city's parkway trees, mostly ficus, carob and liquidambar planted with the tracts, grow toward that wet pipe and are the most common finding on a Westminster sewer camera inspection. The soil itself is alluvial clay that swells when wet and shrinks through the dry season, and six decades of that cycle has offset joints under most of the older streets.

Sewers and permits

Westminster is one of the few Orange County cities that does not run its own sewers. The Midway City Sanitary District operates the local collection system for the city and for Midway City, and the lateral from the house to the connection at the district main is the property owner's responsibility, including the part under the parkway and sidewalk. Lateral repair or replacement needs a plumbing permit from the City of Westminster, and anything in the sidewalk, parkway or street needs an encroachment permit and an inspection before the pit is closed. The contractor should pull both and say so in the quote.

Which trenchless method fits a Westminster lateral

• Sewer pipe lining fits most of the city: clay with root-intruded joints and small offsets that still holds shape and slope, and channeled cast iron under a slab. A cured-in-place liner from the cleanout seals every joint and crack in one pass and stops the groundwater infiltration along with the roots.
• Pipe bursting fits a collapsed section, a belly where the soil washed out, or a line that needs to be upsized. Two small pits and a new fused polyethylene pipe on the old alignment.
• Sectional point repair handles one crushed joint under a driveway or one root ball on an otherwise sound line.

Crews that handle trenchless sewer repair in Westminster work these same tracts week after week, and a good one will tell you from the footage which method fits before quoting one.

What the job looks like

A camera inspection maps the line and marks every defect on the ground with its depth. Hydro jetting clears roots, scale and silt so the pipe wall can be seen and, if the line is being lined, so the resin bonds to clean pipe. In Westminster the crew may need to pump down standing groundwater before a liner goes in, which is routine here. Lining runs from the cleanout at the house; bursting needs a small pit at each end of the run. Most residential jobs finish in a day, with water off for a few hours during a liner cure, and you should receive the before-and-after footage. how a trenchless repair is sequenced from inspection to cure is worth reading before the crew arrives.

To compare installers who have been checked for licensing and CIPP training, you can find a verified CIPP contractor through an independent directory.

Sectional Point Repair in Westminster

Fix the spot, not the line

A sectional point repair treats a short length of pipe, usually two to six feet, instead of the whole lateral. A short fiberglass or felt liner saturated with resin is positioned over the defect on an inflatable packer, pressed against the wall, and cured in place. The rest of the line is untouched. Where the defect cannot be lined, the alternative is a small excavation at that exact spot, made possible because the camera and locator have already marked it to within inches.

When it makes sense

One identifiable defect, or two or three close together, on a line whose remaining footage is sound: a joint crushed when a driveway was poured over it, a single root-intruded joint under a parkway tree, a break where the lateral crosses another utility trench, or the transition where under-slab cast iron meets the clay or ABS running to the street.

When it does not

If the camera shows the same defect at every joint, or channeling along the whole bottom of a cast iron line, fixing one spot moves the next backup a few feet down the pipe. A full liner costs more today and far less over the next few years.

A fair test

Ask to see footage of the pipe on both sides of the proposed repair. If it is clean for the full run, a point repair is honest and economical. If it is not, ask why a full liner was not proposed.

ZIP codes served in Westminster

Sectional Point Repair is available throughout Westminster, including ZIP codes 92683, 92684, 92685.

More trenchless services in Westminster

Questions we hear in Westminster